Home Page
   Articles
       links
About Us    
Traders        
Recipes            
Latest Articles
Small bale hay
Page 1, 2  Next
 
Post new topic   Reply to topic    Downsizer Forum Index -> Land Management
Author 
 Message
Nick



Joined: 02 Nov 2004
Posts: 34535
Location: Hereford
PostPosted: Thu Jul 14, 16 7:06 pm    Post subject: Small bale hay Reply with quote
    

Can the house reassure me that once baled, hay won't come to much harm if it sits in the field for a couple of days with the odd light shower? I'm assuming it'll continue to dry with only the surface getting damp and then drying in the wind and sun?

Looks like it might be done the moment I go away for two days at work. And the forecast shows light showers.

dpack



Joined: 02 Jul 2005
Posts: 45326
Location: yes
PostPosted: Thu Jul 14, 16 7:52 pm    Post subject: Reply with quote
    

should be ok ,just be sure to collect and stack it after a drying phase.

tis years since i have been involved in hay making but i seem to recall that small bales are quite well "thatched" against a bit of rain

Slim



Joined: 05 Mar 2006
Posts: 6531
Location: New England (In the US of A)
PostPosted: Thu Jul 14, 16 8:58 pm    Post subject: Reply with quote
    

Probably best to lay them so the rain hits the hay "lengthwise" and not the end where it may flow in better. This would also keep those ends from wicking moisture up from the ground, so that only the very bottom layer and top layer get damp (hopefully)

I would still monitor the bales closely before storage. It all depends on your system and your equipment. Can you put a loosely filled wagon under cover somewhere to dry out again before tight stacking?

Is this hay for feed, or just meant to be mulch? After a few days of rains it won't be much value for feed, except maybe the very core of the bale

I just googled around since I didn't have a good source of the top of my head, but here's this: https://www.extension.umn.edu/agriculture/forages/utilization/preserving-the-value-of-dry-stored-hay/
Quote:
Dry matter losses caused by the combination of soil moisture and precipitation can be fairly large. For example, in Oklahoma, researchers found 13.1% dry matter loss for uncovered storage on the ground versus 2% loss for covered storage on pallets. Wisconsin researchers found 10.9% loss for uncovered storage on the ground versus 4.6% in a barn. In the Morris study, average dry matter losses in the uncovered piles on sod were 11.2% versus 2.3% in the barn. It appears that for eight to nine months of storage, you can expect a 6 to 11 percentage unit advantage by keeping bales off wet ground and under cover.

Besides losing dry matter, uncovered hay also loses quality as determined by nutritional analysis and by appearance. The loss in dry matter reduces weight available for sale and the loss in quality can have a large impact on animal performance and on hay value. For example, in our study at Morris, the internal parts of bales stored in the shed had a relative feed value (RFV) of 133 and the bottom six inches of the bales at the bottom of the pile had an RFV of 106. The internal parts of bales stored uncovered, outside on sod had an RFV of 114 and the external parts of the bales had RFVs ranging from 55 to 107.

Ty Gwyn



Joined: 22 Sep 2010
Posts: 4561
Location: Lampeter
PostPosted: Thu Jul 14, 16 9:01 pm    Post subject: Reply with quote
    

Not recommended for small bales,fine for round bales.

Slim



Joined: 05 Mar 2006
Posts: 6531
Location: New England (In the US of A)
PostPosted: Thu Jul 14, 16 9:02 pm    Post subject: Reply with quote
    

Ty Gwyn wrote:
Not recommended for small bales,fine for round bales.


Even that's not great if you can help it. Something like 30% of the bale is in the outer 6 inches which where you lose your quality and dry matter.....

Ty Gwyn



Joined: 22 Sep 2010
Posts: 4561
Location: Lampeter
PostPosted: Thu Jul 14, 16 9:04 pm    Post subject: Reply with quote
    

Slim wrote:
Ty Gwyn wrote:
Not recommended for small bales,fine for round bales.


Even that's not great if you can help it. Something like 30% of the bale is in the outer 6 inches which where you lose your quality and dry matter.....



If you store round bales to soon,you have a danger of a fire,
And lose all your dry matter.

Slim



Joined: 05 Mar 2006
Posts: 6531
Location: New England (In the US of A)
PostPosted: Thu Jul 14, 16 9:11 pm    Post subject: Reply with quote
    

Ty Gwyn wrote:
Slim wrote:
Ty Gwyn wrote:
Not recommended for small bales,fine for round bales.


Even that's not great if you can help it. Something like 30% of the bale is in the outer 6 inches which where you lose your quality and dry matter.....



If you store round bales to soon,you have a danger of a fire,
And lose all your dry matter.


Nobody wants a barn fire, but at that point they were wetter than you were hoping for anyway and you're losing quality there as well. (not that weather is likely to cooperate with anybody during haymaking......)

Quote:
Storing hay inside a well ventilated barn will result in the least amount of loss. Humid regions... are good candidates for inside bale storage. Humid areas are also prone to bales being too wet at time of harvest. Bales too high in moisture can heat and catch fire. Thus, tightly packing bales into a barn can end with the loss of the shed if a bale catches fire.

Quote:
Storing hay can be improved several ways. If you do plan to store hay inside, invest in a hay moisture probe that will help you determine if hay if fit to pack into a barn with little risk of fire. If you plan to store hay outside, improve the drainage of the area. Run bale rows up and down a sloping area. You can stack bales on pallets or railroad ties. You may look into a layer of coarse rock that will keep bale to soil contact at a minimum. Make sure bales are not touching and avoid stacking bales outside without tarping. Tarps are a lower cost investment than sheds. If tarps are secured properly and the bottom of the bale is kept dry, expect big improvements in bale storage. Keeping moisture off and away from bales will help reduce hay storage losses.


From: https://www.cattlenetwork.com/advice-and-tips/stockerpasturerangeland/storing-hay-properly

Slim



Joined: 05 Mar 2006
Posts: 6531
Location: New England (In the US of A)
PostPosted: Thu Jul 14, 16 9:17 pm    Post subject: Reply with quote
    

Here's a nice page on square bales and rain: https://www.afia.org.au/index.php/fodder-care/hay-factsheets/making-quality-hay/143-managing-hay-after-it-rains

Ty Gwyn



Joined: 22 Sep 2010
Posts: 4561
Location: Lampeter
PostPosted: Thu Jul 14, 16 10:13 pm    Post subject: Reply with quote
    

Slim wrote:
Ty Gwyn wrote:
Slim wrote:
Ty Gwyn wrote:
Not recommended for small bales,fine for round bales.


Even that's not great if you can help it. Something like 30% of the bale is in the outer 6 inches which where you lose your quality and dry matter.....



If you store round bales to soon,you have a danger of a fire,
And lose all your dry matter.


Nobody wants a barn fire, but at that point they were wetter than you were hoping for anyway and you're losing quality there as well. (not that weather is likely to cooperate with anybody during haymaking......)

Quote:
Storing hay inside a well ventilated barn will result in the least amount of loss. Humid regions... are good candidates for inside bale storage. Humid areas are also prone to bales being too wet at time of harvest. Bales too high in moisture can heat and catch fire. Thus, tightly packing bales into a barn can end with the loss of the shed if a bale catches fire.

Quote:
Storing hay can be improved several ways. If you do plan to store hay inside, invest in a hay moisture probe that will help you determine if hay if fit to pack into a barn with little risk of fire. If you plan to store hay outside, improve the drainage of the area. Run bale rows up and down a sloping area. You can stack bales on pallets or railroad ties. You may look into a layer of coarse rock that will keep bale to soil contact at a minimum. Make sure bales are not touching and avoid stacking bales outside without tarping. Tarps are a lower cost investment than sheds. If tarps are secured properly and the bottom of the bale is kept dry, expect big improvements in bale storage. Keeping moisture off and away from bales will help reduce hay storage losses.


From: https://www.cattlenetwork.com/advice-and-tips/stockerpasturerangeland/storing-hay-properly

Ty Gwyn



Joined: 22 Sep 2010
Posts: 4561
Location: Lampeter
PostPosted: Thu Jul 14, 16 10:17 pm    Post subject: Reply with quote
    

[quote="Ty Gwyn:1464928"][quote="Slim:1464924"]
Ty Gwyn wrote:
Slim wrote:
Ty Gwyn wrote:
Not recommended for small bales,fine for round bales.


Even that's not great if you can help it. Something like 30% of the bale is in the outer 6 inches which where you lose your quality and dry matter.....



If you store round bales to soon,you have a danger of a fire,
And lose all your dry matter.


Nobody wants a barn fire, but at that point they were wetter than you were hoping for anyway and you're losing quality there as well. (not that weather is likely to cooperate with anybody during haymaking......)


I take it you have handled a lot of big bale hay?

dpack



Joined: 02 Jul 2005
Posts: 45326
Location: yes
PostPosted: Thu Jul 14, 16 10:48 pm    Post subject: Reply with quote
    

having read their wise words im wondering if wilby was being optimistic after badly timed rain as the stuff had just been baled, tis close on 50 yrs ago

he was pretty chuffed to have a baler rather than a fork and cart .

Nick



Joined: 02 Nov 2004
Posts: 34535
Location: Hereford
PostPosted: Fri Jul 15, 16 7:51 am    Post subject: Reply with quote
    

Thanks. I think the answer will be what will be, will be. I've no choice in work and no control over the weather.

It's food, but only for horses and we have a massive excess*, so they can just eat more. Or starve. I'm easy.

As for tools, I've a teenager or two and a small trailer. They'll be stacked in a series of small sheds on pallets.

Sun through Wednesday would be the perfect answer.

*of both hay, and arguably, horses.

Slim



Joined: 05 Mar 2006
Posts: 6531
Location: New England (In the US of A)
PostPosted: Fri Jul 15, 16 11:30 am    Post subject: Reply with quote
    

Ty Gwyn wrote:
Slim wrote:
Ty Gwyn wrote:
Slim wrote:
Ty Gwyn wrote:
Not recommended for small bales,fine for round bales.


Even that's not great if you can help it. Something like 30% of the bale is in the outer 6 inches which where you lose your quality and dry matter.....



If you store round bales to soon,you have a danger of a fire,
And lose all your dry matter.


Nobody wants a barn fire, but at that point they were wetter than you were hoping for anyway and you're losing quality there as well. (not that weather is likely to cooperate with anybody during haymaking......)



I take it you have handled a lot of big bale hay?


Nope, I'm more veggies background and have been learning about forage quality, etc over the past few years. More of an academic than a practitioner these days. Sorry if I have a tone of more experience than I should!

I agree that a barn fire is worse than quality and dry matter loss! I'm just pointing out that if your bales are at risk of spontaneous combustion than they were baled wetter than you would be aiming for. (Baleage is a totally different story, and probably what I would be trying to do if I were feeding cows/sheep)

dpack



Joined: 02 Jul 2005
Posts: 45326
Location: yes
PostPosted: Fri Jul 15, 16 11:54 am    Post subject: Reply with quote
    

Nick wrote:
Thanks. I think the answer will be what will be, will be. I've no choice in work and no control over the weather.

It's food, but only for horses and we have a massive excess*, so they can just eat more. Or starve. I'm easy.

As for tools, I've a teenager or two and a small trailer. They'll be stacked in a series of small sheds on pallets.

Sun through Wednesday would be the perfect answer.

*of both hay, and arguably, horses.


if you have teenagers and a tarp perhaps making a tarp sandwich of them as soon as they emerge from the bailer would avoid them getting wet before there is chance to move and stack them properly.

Slim



Joined: 05 Mar 2006
Posts: 6531
Location: New England (In the US of A)
PostPosted: Fri Jul 15, 16 12:02 pm    Post subject: Reply with quote
    

Shouldn't the teenagers be following the baler and picking up the bales anyway?

Post new topic   Reply to topic    Downsizer Forum Index -> Land Management All times are GMT
Page 1, 2  Next
Page 1 of 2
View Latest Posts View Latest Posts

 

Archive
Powered by php-BB © 2001, 2005 php-BB Group
Style by marsjupiter.com, released under GNU (GNU/GPL) license.
Copyright © 2004 marsjupiter.com